Generalaire M3 User Manual download pdf (Page 2)

OWNER'S NAME

Nom du propriétaire:

MODEL M3 Humidistat

Humidistat MODÈLE M3

WARRANTY REGISTRATION

Enregistrement de la garantie

STREET ADDRESS

Adresse:

DEALER'S NAME

Nom du marchand:

DATE OF INSTALLATION / DATE DE INSTALLATION

CITY

Ville:

POSTAL CODE

Code postal:

STATE

Province:

STREET ADDRESS

Adresse:

CITY

Ville:

POSTAL CODE

Code postal:

STATE

Province:

FORM NO. M3-07 (FILE 13143)

Litho in U.S.A.

LIMITED WARRANTY

This humidistat, if properly registered by the return of the warranty registration card to the

manufacturer, is warranted to the consumer against defects in materials and workmanship for a

period of two years from the date of installation. Any defective parts will be repaired without

charge except for removal, reinstallation and transportation costs. To obtain repair service

under this limited warranty, the consumer must send the defective part or the complete

humidistat to the manufacturer.

THERE ARE NO EXPRESS WARRANTIES COVERING THIS HUMIDISTAT OTHER THAN

AS SET FORTH ABOVE, THE IMPLIED WARRANTIES OF MERCHANTABILITY AND

FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED IN DURATION TO ONE YEAR.

THE MANUFACTURER ASSUMES NO LIABILITY IN CONNECTION WITH THE

INSTALLATION OR USE OF THIS PRODUCT, EXCEPT AS STATED IN THIS LIMITED

WARRANTY. THE MANUFACTURER WILL IN NO EVENT BE LIABLE FOR INCIDENTAL

OR CONSEQUENTIAL DAMAGES.

This limited warranty gives you specific legal rights, and you may also have other rights which

vary from state to state. Some states do not allow either limitations on implied warranties, or

exclusions from incidental or consequential damages, so the above exclusion and limitation

may not apply to you.

Any questions pertaining to this limited warranty should be addressed to the manufacturer.

(U.S.A.:The manufacturer has elected not to make available the informal dispute settlement

mechanism which is specified in the Magnuson-Moss Warranty Act.)

GENERAL FILTERS, INC. CANADIAN GENERAL FILTERS, LTD.

43800 GRAND RIVER AVE. 39 CROCKFORD BLVD.

NOVI, MICHIGAN 48375-1115 SCARBOROUGH, ONTARIO M1R3B7

WWW.GENERALAIRE.COM WWW.CGFPRODUCTS.COM

TROUBLESHOOTING

SYMPTOM DIAGNOSTIC STEPS

2 Check voltage at humidifier control terminals.

There should be no voltage for an Elite Room Steam

or a 1137 Power Humidifier.

Voltage should be 20-30 VAC for most others.

3 Inspect humidifier wiring. Refer to wiring diagrams.

DO NOT LEAVE IN "ON" POSITION, OVER HUMIDIFICATION MAY OCCUR.

1 Set thermostat to operate both furnace burner and blower.

Operation may be necessary for system power.

No Humidifier

Operation in

"ON" position

1 Humidity level in the home is higher than knob setting.

Humidifier control will not operate the humidifier until

humidity level is reduced.

Humidifier

operation in

"ON" position

only

1 When the humidity in the home is less than the knob

setting, the control will operate humidifier until the

humidity is higher. Reduce knob setting.

2 Use "ON" position. Verify that the humidifier operates.

1 Check voltage at humidifier control terminals.

There should be no voltage for an Elite Room Steam

or a 1137 Power Humidifier.

Voltage should be 20-30 VAC for most others.

2 If mounted on return air duct, make sure humidifier control

is at least 24" upstream of humidifier's air discharge.

Humidifier

turns on and

off repeatedly

3 Remove wires from control terminals, If humidifier

continues to operate, check solenoid valve.

Humidifier

operation

continuous

DIAGRAM 3 WIRING 120V. 1137 POWER HUMIDIFIER

HUMIDISTAT

SOLENOID VALVE

FAN

MOTOR

ISOLATION

RELAY

BLK

WHT

YEL

120 V 60 HZ

WHT

BLK

BLU

H U M ID IS T A T

DIAGRAM 4 WIRING 230V. ELITE DUCT STEAM HUMIDIFIER

STEAM HUMIDIFIER

CONTROL MODULE

GND

TAM

RELAY 1

RELAY 2

EV2

EV1

EV3

ID2

GND

ID1

SCR-

SCR+

+VR

SET

GND

R G V

DIP

Switch

FUSE

N O

TO FAN

FROM FAN

POWER SUPPLY

12500 AIR

PRESSURE

SWITCH

FACTORY

INSTALLED

JUMPER

FIELD SUPPLIED

2 POLE SINGLE

THROW RELAY

FACTORY

INSTALLED

JUMPER

HUMIDISTAT

DIAGRAM 5 WIRING 230V. ELITE ROOM STEAM HUMIDIFIER

+VR SET GND AB AB

TERMINALS ON

ELITE STEAM BOARD

1 2 3 4

Comments to this Manuals

No comments

Generalaire M3 User Manual Page 2

Comments to this Manuals

Related products and manuals for Water equipment Generalaire M3